Total organic carbon analyzer BC-40A is instrumental analysis Beijing BBEFprecision instrument company independent research and development of high precision of total organic carbon. Products using the conductivity differencedetection technology, high detection precision, short response time. Products comply with national regulations and standards, testing requirements of on-line and off-line can meet the pharmaceutical water, water for injection, ultra pure water and deionized water.

水有積碳TOC分析儀工作原理

The working principle of a.

水有積碳TOC分析儀采用紫外氧化的原理，將樣品中的有機物氧化為二氧化碳，二氧化碳的測試采用的是直接電導率法，通過測試經過氧化反應的樣品的總碳含量和未經過氧化反應的樣品總無機碳的含量差值來測定總有機碳含量，即：總有機碳（TOC）=總碳（TC）-總無機碳（TIC）。

The instrument adopts the principle of UV oxidation, the oxidation of organic matterin the samples into carbon dioxide, carbon dioxide is tested by direct conductivity,total carbon content by testing through oxidation reaction of the sample and thesample without content difference of total inorganic carbon oxidation reaction to the determination of total organic carbon content, namely: Total organic carbon (TOC)= total carbon (TC) - Total inorganic carbon (TIC).

水有積碳TOC分析儀產品特點

Two. Product features

1.儀器采用便攜設計，使用輕便，方便移動至取樣點。

The 1 instrument using portable design, easy use, convenient moving to the sampling point.

2.采用嵌入式系統，觸摸屏設計，純中文操作方便簡易。

2 the use of embedded system, touch screen design, the operation is very simpleand pure Chinese.

3.針對制藥用水（TOC含量在1000ppb以下）總有機碳含量的檢測設計，進行檢測。

3 for pharmaceutical water (TOC content below 1000ppb) detecting design total organic carbon content, detection.

4.配備大量的儲存空間，能夠存儲大量的測試數據。

4 is equipped with a lot of storage space to store a large number of test data.

5.中文打印，輸出測試參數、測試結果。

5 Chinese print output test parameters and test results.

6.在使用、貯存和更換過程中不需要氣體或試劑，無移動部件，減少維修和維護成本。

6 in the use, storage and replacement is not needed in the process of gas orreagent, no moving parts, reduce the maintenance cost and maintenance cost.

7.當測試樣品濃度超過規定限度，儀器能夠自動報警，并輸出控制信號。

7 when the sample concentration exceeds the specified limit, the instrument canautomatically alarm, and output control signal.

8.符合國家2010版《中國藥典》規定的測試方案，可以提供 IQ/OQ/PQ 服務。

8 in line with national 2010 version of "Chinese Pharmacopoeia" provisions of the testing scheme can provide IQ/OQ/PQ service.

TOC總有機碳分析儀性能規格:

Three, performance specifications:

測量范圍：0.001mg/L～1.000 mg/L

Measuring range: 0.001mg/L ~ 1 mg/L

精度：±4% 測試范圍

Accuracy: + 4% test range

分辨率：0.001mg /L

Resolution: 0.001mg /L

分析時間：連續分析

Analysis: analysis of continuous time

響應時間：6分鐘之內

Response time: 6 minutes

檢測極限：0.001mg /L

The detection limit: 0.001mg /L

樣品溫度：1- 90℃

The sample temperature: 90 C 1-

重復性誤差：≤ 3%

Repeatability error: less than or equal to 3%

電源要求/功能：220V

Power requirements / function: 220V

顯示屏：彩色觸摸屏

The display screen: color touch screen

TOC總有機碳分析儀應用領域：

The application field of four:

制藥用水（純化水、注射用水）的在線監測和實驗室測試，以及清潔驗證；

Pharmaceutical water (purified water, water for injection) online monitoring and laboratory testing, and cleaning validation;

環保測試、電子行業、食品行業等。

Environmental testing, electronic industry, food industry etc..

水有積碳TOC分析儀產品說明:

Product description:

總有機碳（TOC）分析儀采用世界的雙波長紫外氧化技術，精度高、靈敏度高。高性能CPU，觸摸屏智能化控制，具有離線分析和在線分析選配功能，配制外置式打印機，人性化的設計理念，更換UV燈和泵管不用拆開機箱，操作簡單、方便，實現了分析儀器國產化。符合《中國藥典》2010版附錄 VIII R制藥用水中總有機碳測定法，滿足藥典對儀器的要求：①TOC=TC-TIC，②系統適用性試驗，③檢測靈敏度（等于或小于0.05mg/L）。

Total organic carbon (TOC) analyzer using dual wavelength ultraviolet oxidation technology to the world's leading, high precision, high sensitivity. High performance CPU, touching screen inligent control, with offline analysis and online analysis ofthe matching function, preparation of external printer, humanized design idea,replacing the UV lamp and the pump not to open the box, the operation is simple and convenient, realized the localization of instrument analysis. Consistent with the "Chinese Pharmacopoeia" 2010 Edition appendix VIII R pharmaceutical water total organic carbon determination, meet the Pharmacopoeia requirements of instruments: TOC=TC-TIC, applicability test of the system, the detection sensitivity(equal to or less than 0.05mg/L).

水有積碳TOC分析儀工作原理

Working principle

樣品中的有機物在紫外線及二氧化鈦廣催化的作用下被氧化成二氧化碳，采用電導率檢測技術測定二氧化碳，通過電導率傳感器檢測經氧化反應器氧化后的樣品總碳與電導率傳感器檢測未經氧化反應器氧化的樣品總無機碳之差，獲得樣品中總有機碳含量（TOC=TC-TIC）。

Organic matter in the samples were oxidized to carbon dioxide in ultraviolet lightand TiO2 wide catalytic role, determination of carbon dioxide detection by electrical conductivity, conductivity sensor detection through the oxidation reaction of total carbon samples is oxidized and the conductivity sensor detection without differencesample total inorganic carbon oxidation reactor for oxidation, obtain the total organic carbon content of sample in (TOC=TC-TIC).

水有積碳TOC分析儀應用范圍

The scope of application

1. 該儀器可用于檢測制藥工業中純化水、注射用水和去離子水中有機碳的濃

1 the instrument can be used for the purification of organic carbon in water anddeionized water and injection water detection in pharmaceutical industryconcentration

度；也可用于半導體行業中超純水TOC的檢測。

Degree; also can be used for detection of ultra pure water TOC semiconductor industry.

2. 在制藥領域和生物化學領域清潔驗證過程中，可用于驗證清潔效果。

2 in the pharmaceutical field and the field of bio chemical cleaning validationprocess, can be used to validate the cleaning effect.

3. 該儀器具有在線檢測功能，可以在線監測制藥工業的制水系統、半導體工業

3 the instrument has the function of on-line detection, can produce water system,the semiconductor industry on-line monitoring of pharmaceutical industry

的超純水制備系統和晶片工藝過程、電廠去離子水制備過程等。

The preparation of ultra pure water system and wafer process, deionized water forpower plant preparation process.

水有積碳TOC分析儀主要特征:

The main features of:

★高精度、高靈敏度，操作簡單。

* high precision, high sensitivity, simple operation.

★人性化操作界面，有一鍵運行功能，自動管路清洗功能。

* the humanized operation interface, a key operating functions, automatic tubecleaning function.

★高性能CPU，觸摸屏設計，超大640*480點陣真彩顯示器。

* high performance CPU, touch screen design, large 640*480 dot matrix colordisplay.

★不用拆開機箱更換UV燈和泵管。

* Don't open the box to replace the UV lamp and the pump.

★檢測上限可設定，自動上限報警功能。

* the detection limit can be set automatically limit alarm function.

★具有RS232數據接口，歷史數據可存儲6個月。

It has a RS232 data interface, the historical data can be stored for 6 months.

★離線檢測和在線檢測可選配。

* offline detection and online detection of optional.

★具有微型打印機接口（打印機外置）。

* with micro printer (printer external).

水有積碳TOC分析儀技術參數:

Technical parameters:

◆電源：AC220V±22V

The electrical source: AC220V + 22V

◆頻率：50HZ±1HZ

The frequency: 50HZ + 1HZ

◆功率：95W

The power: 95W

◆外形尺寸：340*390*145mm

The size: 340*390*145mm

◆重量：15kg

The weight: 15kg

◆TOC檢測范圍：0.001mg/l-1.0mg/l

The TOC detection range: 0.001mg/l-1.0mg/l

◆檢測精度：±5%

The detection accuracy: + 5%

◆檢測時間：≤4min/次

The detection time is less than or equal to 4min/

◆響應時間：≤15min

The response time: less than 15min

◆樣品流量：0.5ml/min

The sample flow rate: 0.5ml/min

◆樣品溫度：1-95℃

The sample temperature: 1-95 degrees

◆環境濕度：≤85%RH

The humidity of the environment: less than 85%RH

◆環境溫度：10-40℃

The environment temperature: 10-40 degrees

◆重復誤差：≤3%

The repeated error is less than or equal to 3%:

◆線性誤差：±5%

The linear error: + 5%

以上信息由企業自行提供，信息內容的真實性、準確性和合法性由相關企業負責，化工儀器網對此不承擔任何保證責任。
溫馨提示：為規避購買風險，建議您在購買產品前務必確認供應商資質及產品質量。